Skip to main content
  • Study protocol
  • Open access
  • Published:

The effects of water lubrication of tracheal tubes on post-intubation airway complications: study protocol for a randomized controlled trial

Abstract

Background

Water is known to have lubricating properties, thus it is used for lubrication of tracheal tubes to reduce airway injuries caused by intubation. However, there is no definite evidence to substantiate the beneficial effects of lubricating tracheal tubes using water for attenuating airway injuries. Moreover, the lubrication pretreatment may cause contamination of the tube, leading to respiratory infections. Therefore, this trial aims to assess whether no pretreatment of tracheal tubes does not increase post-intubation airway complications as compared with water lubrication of tubes.

Methods/design

This is a prospective, double-blind, single-center, parallel-arm, noninferiority, randomized controlled trial to be conducted in participants aged 20–80 years who are undergoing elective surgery under general anesthesia with orotracheal intubation. Participants are randomly assigned into one of two groups depending on whether intubation is performed using a tracheal tube lubricated with water (n = 150) or without any pretreatment (n = 150). The primary outcome is the incidence of sore throat at 0, 2, 4, and 24 h after surgery, which is analyzed with a noninferiority test. The secondary outcomes are the incidence and severity of postoperative hoarseness, oropharyngeal injuries, and respiratory infections.

Discussion

Because we hypothesized that lubricating tracheal tubes using water has no advantage in reducing airway injuries associated with intubation, we will compare the incidence of sore throat, which is the most common complaint after intubation, in a noninferiority manner. This is the first randomized controlled trial to investigate the possibly beneficial or harmful effects of lubricating tracheal tubes using water before intubation. We expect that this trial will provide useful evidence to formulate a protocol for preparing tracheal tubes before intubation.

Trial registration

This trial is registered at ClinicalTrials.gov on 1 July 2015 (NCT02492646)

Peer Review reports

Background

Water is commonly used for lubrication of various medical devices, including tracheal tubes, because it is known to have lubricating properties [16]. However, some other lubricants have shown no beneficial effects on reducing airway injuries associated with tracheal intubation such as sore throat or hoarseness [79]. Moreover, there has been no evidence as to whether the lubrication of tracheal tubes using water decreases airway injuries caused by intubation, so this conventional pretreatment seems to have been performed without any validation for its advantage.

Besides, tracheal tubes are known to be a major source of respiratory infections in patients undergoing mechanical ventilation [1013]. Moreover, the wet condition of the tube may aggravate the proliferation of respiratory pathogens, thereby increasing the risk of infection [14]. Any external treatment applied to the tracheal tube before intubation can lead to contamination of the tube as opposed to keeping the tube inside the sterile packing until intubation. Thus, lubricating tracheal tubes using water may even be harmful, increasing the probability of respiratory infection.

Therefore, we conducted a prospective, randomized noninferiority trial to investigate whether no pretreatment of tracheal tubes does not increase post-intubation airway complications as compared with water lubrication of tubes in patients undergoing general anesthesia. We also examine postoperative respiratory infections to evaluate the adverse effects of water lubrication of tracheal tubes.

Methods/design

Study design

This prospective, double-blind, single-center, parallel-arm, noninferiority, randomized controlled trial was approved by the Institutional Review Board of Seoul National University Hospital (version 2.0, reference number: 1506-125-684, validated on 28 July 2015) and registered at ClinicalTrials.gov (NCT02492646). This trial is being conducted in a tertiary university hospital in Seoul, South Korea. We describe the protocol of our study according to the Standard Protocol Items: Recommendations for Interventional Trials (SPIRIT) guidelines (Fig. 1 and Additional file 1). The final report of this protocol will follow both the general Consolidated Standards of Reporting Trials (CONSORT) Statement as well as its extension to noninferiority trials.

Fig. 1
figure 1

Standard Protocol Items: Recommendations for Interventional Trials (SPIRIT) flow diagram: schedule of enrollment, interventions, and assessments. *: mean blood pressure, heart rate, and pulse oximetry, †: examination of the presence of blood on the tube surface or in the oral cavity; T1: before intubation, T2: intubation, T3: emergence period, T4: at post-anesthesia care unit, T5: postoperative 2 h, T6 : postoperative 4 h, T7: postoperative 24 h

Participants

Potential participants who meet the inclusion criteria are recruited at outpatient clinics or on the preoperative visit 1 day before surgery, and written informed consents are obtained from all of the participants (by SJY). We enroll participants with American Society of Anesthesiologists physical status 1–3 and aged 20–80 years, who are scheduled for elective surgery under general anesthesia with orotracheal intubation. The exclusion criteria are as follows:

  • Symptoms of sore throat, hoarseness, and respiratory infections as assessed by a study investigator at baseline

  • Gastroesophageal reflux diseases defined by history-taking from patients

  • Congenital or acquired abnormalities of the upper airway

  • Previous airway surgeries

  • Previous history of aspiration

  • Coagulation disorders

  • History of difficult intubation or conditions with an expected difficult airway including Mallampati classification ≥3 or a thyromental distance <6.5 cm

  • Use of airway instruments other than a direct laryngoscope such as a fiberoptic bronchoscope, video laryngoscope, or lighted stylet

  • Anticipated nasotracheal intubation or insertion of a nasogastric tube

Randomization and blinding

After the recruitment, participants are randomly assigned to one of the two groups in a 1:1 ratio depending on whether or not the tracheal tube is lubricated with water before intubation (Fig. 2). A random sequence with 4 or 6 sizes of random blocks (i.e., 4-4-4-6-4-4-6-6…) is generated with an online tool (http://www.randomization.com/) by an assistant not involved in the trial and kept within sealed opaque envelopes. When a patient is enrolled in the trial, an anesthesia nurse opens an envelope and prepares a tracheal tube with the allocated treatment.

Fig. 2
figure 2

Consolidated Standards of Reporting Trials (CONSORT) flow chart

All participants, outcome assessors except for the intubation practitioner (EK), and data analysts are blind to treatment allocation. The unique identification number, which is linked to the randomization schedule, will be managed by an assistant who does not participate in the study. If serious adverse events that threaten the safety of participants (such as death or irreversible injury to the respiratory system) occur, we will immediately stop the intervention, cancel the blinding, and contact the Institutional Review Board.

Withdrawal, dropout, and discontinuation

Participants can refuse to participate in the study and follow-up evaluation after enrollment. Other indications for withdrawal are the following situations: when tracheal intubation is performed by methods other than direct laryngoscopy, such as using a fiberoptic bronchoscope, video laryngoscope, or lighted stylet, and when extubation is not achieved after surgery. If the planned statistical power is not obtained because of a high dropout rate, additional recruitment will be done according to a new randomization.

Confidentiality

Unnecessary individual data including name, social security number, or chart number of participants will not be collected throughout the study period. Only the study code and phone number of the participants will be collected and managed separately. Collected data will be kept confidential until the limited investigators analyze the data. After completion of the study, the collected data will be stored encrypted for 3 years and then discarded.

Intervention

According to random allocation, a disposable tracheal tube (Unomedical, Kedah, Malaysia), which is made of polyvinyl chloride and has a cuff with high-volume and low-pressure characteristics, is pretreated by an anesthesia nurse unaware of the study protocol. Until tracheal intubation, the tube is placed in a 1-L bottle of sterile saline for the experimental group or kept inside the sterile packing for the control group. Tubes with 7.0-mm and 7.5-mm internal diameters are used for women and men, respectively.

After overnight fasting, participants enter the operating room without any premedication. With standard monitoring including electrocardiography, noninvasive arterial blood pressure, and pulse oximetry general anesthesia is induced with intravenous administration of propofol 1.5–2.0 mg/kg and fentanyl 1 mcg/kg. Rocuronium 0.6–0.8 mg/kg is administered for the neuromuscular blockade and train-of-four counts are checked at the adductor pollicis muscle using acceleromyography (TOF-watch®, Organon Ltd., Dublin, Ireland). At a train-of-four count of 0, the tracheal tube, pretreated according to the randomization, is handed to an investigator (EK) who has a 10-year experience in tracheal intubation. The investigator performs tracheal intubation via direct laryngoscopy using either Macintosh 3 or 4 blades. If intubation fails, the tube tip is flexed to make a hockey-stick shape by inserting the stylet inside the tube, and then intubation is reattempted. When intubation fails even using the stylet, other devices such, as a video laryngoscope, fiberoptic bronchoscope, or lighted stylet, are applied. After successful intubation, the intracuff pressure is adjusted to less than 25 cm H2O using a cuff pressure monitor (VBM Medizintechnik GmbH, Sulz am Neckar, Germany) [15].

Anesthesia is maintained with 1.0–1.5 minimum alveolar concentration of desflurane to obtain a bispectral index (A-2000 XP, Aspect Medical Systems, Newton, MA, USA) value of less than 60, and total fresh gas flow is supplied at 2 L/min throughout the operation. All participants receive inhalation with nonhumidified anesthetic gas through a disposable semiclosed breathing circuit using an anesthetic machine (Avance, GE Datex-Ohmeda, Munich, Germany). Mechanical ventilation is performed with a tidal volume of 6–8 ml/kg and a positive end-expiratory pressure of 5–10 cm H2O. The respiratory rate and inspired oxygen fraction are adjusted to maintain an end-tidal carbon dioxide partial pressure of 30–40 mmHg and oxygen saturation by pulse oximetry of 95–100%, respectively.

At the end of surgery, pyridostigmine 0.3 mg/kg and glycopyrrolate 0.01 mg/kg are administered to antagonize the neuromuscular blockade. After gently suctioning the oral secretions from the oropharynx, extubation is carefully performed at a train-of-four ratio above 90% when the participants are able to achieve spontaneous breathing and obey verbal commands.

Measurements

During direct laryngoscopy, the laryngeal view is classified using the Cormack-Lehane classification [16]: grade 1, no difficulty; grade 2, only posterior extremity of the glottis visible; grade 3, only the epiglottis visible; and grade 4, no recognizable structures visible without laryngeal manipulation. The intubation practitioner subjectively evaluates the resistance during advancement of the tube through the glottis using a four-point scale (none, mild, moderate, and severe). Hemodynamic parameters including noninvasive blood pressure, heart rate, and pulse oximetry are recorded immediately before and 1 min after intubation. Intubation time, defined as the duration between the insertion of the laryngoscopic blade into the mouth and the inflation of the endotracheal tube cuff, is measured. Extubation time is defined as the interval from cessation of anesthesia until extubation. After extubation, the presence of blood on the tube surface or in the oral cavity is examined.

An investigator (SMY) blinded to the group assignment evaluates patient-reported sore throat and hoarseness 0, 2, 4, and 24 h after surgery. The severity of sore throat is evaluated using a four-point scale as follows: none, no sore throat; mild, complained of sore throat only upon inquiry; moderate, complained of sore throat without inquiry; severe, change of voice or hoarseness associated with throat pain [17]. Hoarseness is defined as a subjective symptom that is different from the previous voice quality of the patient [18]. The investigator also examines oropharyngeal injuries via direct inspection using a penlight and tongue depressor with regard to the location (posterior pharyngeal wall, uvula, tonsillar fossa, pillar, or others) and type (hyperemia, edema, hematoma, or others) at 2 and 24 h after surgery. The amount of intraoperative and postoperative analgesic drugs is checked until 24 h after surgery.

At 7 days after surgery, the investigator also asks about the symptoms of respiratory infections, such as cough, sputum, rhinorrhea, sore throat, or fever, and whether the patients have been diagnosed with a common cold, tonsillitis, pneumonia, or any other respiratory infectious diseases and prescribed related medications postoperatively. If the patients have been discharged from hospital, they are contacted by telephone and asked about respiratory infections.

Sample size

The primary outcome of this trial is the incidence of postoperative sore throat within 24 h after surgery. Assuming the incidence of 57% in a previous study [17], 135 patients are required in each group to obtain 80% statistical power, 5% risk of type-I error, and 15% noninferiority margin. The margin was determined based on our clinical judgment that the incidence of postoperative sore throat is relatively high (50–60%), so the difference within 15% in the incidence would be considered clinically noninferior. Considering 10% dropout, the estimated sample size is 300 in both groups. The sample size is calculated using a PASS software (version 11.0, NCSS, Kaysville, UT, USA).

Statistical analysis

Both intention-to-treat and per-protocol analyses will be performed and missing data will be imputed with the last observation carried forward value. Continuous variables will be presented as mean and standard deviation or median and interquartile range according to the Kolmogorov-Smirnov test, and categorical variables as number of patients and proportion.

The incidence of postoperative sore throat (primary outcome) will be compared with a noninferiority analysis. The noninferiority of the nonpretreated tube over the water-lubricated tube will be accepted if the upper bound of a 95% confidence interval is below the predetermined noninferiority margin of 15%. For secondary outcomes, continuous variables will be compared with an independent t test or the Mann-Whitney U test and categorical variables with Pearson’s chi-squared test or Fisher’s exact test. All tests are two-sided and P < 0.05 is considered statistically significant. A statistician not involved in data collection will conduct all statistical analyses using SPSS software (version 21.0, SPSS Inc., IBM, Chicago, IL, USA).

Discussion

Lubrication of tracheal tubes is performed to reduce airway damage caused by tracheal intubation although it requires an extra procedure for preparation. Nevertheless, in previous studies several lubricants, such as lidocaine [7, 8] or hydrocortisone [9], failed to show beneficial effects on attenuating airway injuries associated with intubation. Moreover, lubrication of tracheal tubes inevitably increases the risk of contamination as compared with no pretreatment. Therefore, we conduct this prospective, randomized, double-blind trial to obtain evidence regarding the beneficial or harmful effects of lubricating tracheal tubes using water.

Sore throat is the most common complaint after tracheal intubation with its incidence reported as being up to 90% [4, 15, 19]. We thought that if lubricating tracheal tubes using water was effective in reducing airway injuries caused by intubation, it may primarily affect the incidence of postoperative sore throat, so we consider this as the primary outcome of our trial. We evaluate sore throat at several time points because it is known to occur within 24 h after surgery with varying incidence and severity [17, 20]. Because we hypothesized that lubricating tracheal tubes using water would have no advantage for reducing postoperative sore throat, we will compare its incidence in a noninferiority manner. We also examine hoarseness and oropharyngeal injuries to obtain more evidence for airway injuries associated with intubation [2123].

Lubricating tracheal tubes using water might be effective for attenuating airway injuries, but it can increase the chance of contamination and infection. Moreover, water may aggravate the proliferation of respiratory pathogens, worsening the infections [14]. Therefore, we evaluate the clinical symptoms of respiratory infections within 7 days after surgery.

To the best of our knowledge, this is the first randomized controlled trial to investigate the probable advantage and disadvantages of lubricating tracheal tubes using water, which has been conventionally performed for the pretreatment of tracheal tubes for intubation. Therefore, we expect that this trial may provide useful evidence to formulate a protocol for preparing tracheal tubes before intubation.

Trial status

The recruitment commenced in August 2015 and aims to enroll 300 participants for the trial. It is anticipated that recruitment will end by January 2017.

References

  1. Kim HJ, Kim DE. Water lubrication of stainless steel using reduced graphene oxide coating. Sci Rep. 2015;5:17034.

    Article  CAS  PubMed  PubMed Central  Google Scholar 

  2. Panman MR, Bakker BH, den Uyl D, et al. Water lubricates hydrogen-bonded molecular machines. Nat Chem. 2013;5:929–34.

    Article  CAS  PubMed  Google Scholar 

  3. Taylor AM, Hung OR, Kwofie K, et al. Removal of the stylet from the tracheal tube: effect of lubrication. Anaesthesia. 2012;67:885–8.

    Article  CAS  PubMed  Google Scholar 

  4. Estebe JP, Delahaye S, Le Corre P, et al. Alkalinization of intra-cuff lidocaine and use of gel lubrication protect against tracheal tube-induced emergence phenomena. Br J Anaesth. 2004;92:361–6.

    Article  CAS  PubMed  Google Scholar 

  5. Briscoe WH, Titmuss S, Tiberg F, et al. Boundary lubrication under water. Nature. 2006;444:191–4.

    Article  CAS  PubMed  Google Scholar 

  6. Schaefer HG, Kaufmann MA, Marsch SC, Rudin H. Is normal saline an acceptable alternative to silicone for lubricating fibrescopes? Eur J Anaesthesiol. 1993;10:227–30.

    CAS  PubMed  Google Scholar 

  7. Sumathi PA, Shenoy T, Ambareesha M, Krishna HM. Controlled comparison between betamethasone gel and lidocaine jelly applied over tracheal tube to reduce postoperative sore throat, cough, and hoarseness of voice. Br J Anaesth. 2008;100:215–8.

    Article  CAS  PubMed  Google Scholar 

  8. Soltani HA, Aghadavoudi O. The effect of different lidocaine application methods on postoperative cough and sore throat. J Clin Anesth. 2002;14:15–8.

    Article  CAS  PubMed  Google Scholar 

  9. Stride PC. Postoperative sore throat: topical hydrocortisone. Anaesthesia. 1990;45:968–71.

    Article  CAS  PubMed  Google Scholar 

  10. Feldman C, Kassel M, Cantrell J, et al. The presence and sequence of endotracheal tube colonization in patients undergoing mechanical ventilation. Eur Respir J. 1999;13:546–51.

    Article  CAS  PubMed  Google Scholar 

  11. Smith JR, Howland WS. Endotracheal tube as a source of infection. J Am Med Assoc. 1959;169:343–5.

    Article  CAS  PubMed  Google Scholar 

  12. Gibbs K, Holzman IR. Endotracheal tube: friend or foe? Bacteria, the endotracheal tube, and the impact of colonization and infection. Semin Perinatol. 2012;36:454–61.

    Article  PubMed  Google Scholar 

  13. Sottile FD, Marrie TJ, Prough DS, et al. Nosocomial pulmonary infection: possible etiologic significance of bacterial adhesion to endotracheal tubes. Crit Care Med. 1986;14:265–70.

    Article  CAS  PubMed  Google Scholar 

  14. Cardinal P, Jessamine P, Carter-Snell C, et al. Contribution of water condensation in endotracheal tubes to contamination of the lungs. Chest. 1993;104:127–9.

    Article  CAS  PubMed  Google Scholar 

  15. McHardy FE, Chung F. Postoperative sore throat: cause, prevention and treatment. Anaesthesia. 1999;54:444–53.

    Article  CAS  PubMed  Google Scholar 

  16. Cormack RS, Lehane J. Difficult tracheal intubation in obstetrics. Anaesthesia. 1984;39:1105–11.

    Article  CAS  PubMed  Google Scholar 

  17. Borazan H, Kececioglu A, Okesli S, Otelcioglu S. Oral magnesium lozenge reduces postoperative sore throat: a randomized, prospective, placebo-controlled study. Anesthesiology. 2012;117:512–8.

    Article  CAS  PubMed  Google Scholar 

  18. Park SH, Han SH, Do SH, et al. Prophylactic dexamethasone decreases the incidence of sore throat and hoarseness after tracheal extubation with a double-lumen endobronchial tube. Anesth Analg. 2008;107:1814–8.

    Article  CAS  PubMed  Google Scholar 

  19. Lev R, Rosen P. Prophylactic lidocaine use preintubation: a review. J Emerg Med. 1994;12:499–506.

    Article  CAS  PubMed  Google Scholar 

  20. Hung NK, Wu CT, Chan SM, et al. Effect on postoperative sore throat of spraying the endotracheal tube cuff with benzydamine hydrochloride, 10% lidocaine, and 2% lidocaine. Anesth Analg. 2010;111:882–6.

    Article  CAS  PubMed  Google Scholar 

  21. Inoue S, Abe R, Tanaka Y, Kawaguchi M. Tracheal intubation by trainees does not alter the incidence or duration of postoperative sore throat and hoarseness: a teaching hospital-based propensity score analysis. Br J Anaesth. 2015;115:463–9.

    Article  CAS  PubMed  Google Scholar 

  22. Ebneshahidi A, Mohseni M. Strepsils® tablets reduce sore throat and hoarseness after tracheal intubation. Anesth Analg. 2010;111:892–4.

    CAS  PubMed  Google Scholar 

  23. Huang YS, Hung NK, Lee MS, et al. The effectiveness of benzydamine hydrochloride spraying on the endotracheal tube cuff or oral mucosa for postoperative sore throat. Anesth Analg. 2010;111:887–91.

    Article  CAS  PubMed  Google Scholar 

Download references

Acknowledgements

The authors are grateful to Sang Gyu Kwak, PhD (Assistant Professor in the Department of Medical Statistics of Catholic University of Daegu) for statistical advice for this trial.

Funding

None.

Availability of data and materials

Not applicable.

Authors’ contributions

EK is responsible for the acquisition, analysis and interpretation of data, and drafting the manuscript. SMY is responsible for the acquisition and interpretation of data. SJY is responsible for the recruiting and managing the patients and acquisition of data. JHB is responsible for the design of the study, interpretation of data, and revising the manuscript. JHS is responsible for the conception and design of the study, interpretation of data, drafting and revising the manuscript. All authors read and approved the final manuscript.

Competing interests

The authors declare that they have no competing interests.

Consent for publication

Not applicable.

Ethics approval and consent to participate

As indicated in the section “Study design,” the Institutional Review Board of Seoul National University Hospital approved this research protocol (version 2.0, reference number: 1506-125-684, validated on 28 July 2015). All participants will be provided with written informed consents as indicated in the “Participants” section.

Author information

Authors and Affiliations

Authors

Corresponding author

Correspondence to Jeong-Hwa Seo.

Additional file

Additional file 1:

SPIRIT Checklist. recommended items to address in a clinical trial protocol and related documents. (PDF 128 kb)

Rights and permissions

Open Access This article is distributed under the terms of the Creative Commons Attribution 4.0 International License (http://creativecommons.org/licenses/by/4.0/), which permits unrestricted use, distribution, and reproduction in any medium, provided you give appropriate credit to the original author(s) and the source, provide a link to the Creative Commons license, and indicate if changes were made. The Creative Commons Public Domain Dedication waiver (http://creativecommons.org/publicdomain/zero/1.0/) applies to the data made available in this article, unless otherwise stated.

Reprints and permissions

About this article

Check for updates. Verify currency and authenticity via CrossMark

Cite this article

Kim, E., Yang, S.M., Yoon, S.J. et al. The effects of water lubrication of tracheal tubes on post-intubation airway complications: study protocol for a randomized controlled trial. Trials 17, 562 (2016). https://doi.org/10.1186/s13063-016-1699-0

Download citation

  • Received:

  • Accepted:

  • Published:

  • DOI: https://doi.org/10.1186/s13063-016-1699-0

Keywords